Product ID:TUN-O-WASH 2400,2400-4
MSDS Date:06/01/1991
FSC:6850
NIIN:01-224-9211
Status Code:A
MSDS Number: CJRRM

CHEMTRONICS INC

8125 COBB CENTER DRIVE
KENNESAW, GA 30152
US

Emergency Phone: 404-424-4888

Info Phone: 404-424-4888

Preparer: M. WATKINS,QC MANAGER

Cage: 21267

THOMPSON ELECTRONIC SUPPLIES INC

UNKNOW KENNESAW, GA 30152 US

Telephone: 770-424-4888/800-645-5244

Cage: 1F026

1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE

CAS: 76-13-1

RTECS: KJ4000000

OSHA PEL 7600 MG/M3;1000 PPM

ACGIH TLV: 7670 MG/M3;1000 PPM

TRICHLOROFLUOROMETHANE

CAS: 75-69-4

RTECS: PB6125000

OSHA PEL 5600 MG/M3;1000 PPM

ACGIH TLV: 1000 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 9000 MG/M3;5000 PPM

ACGIH TLV: 9000 MG/M3;5000 PPM

LD50 LC50 Mixture:NOT PROVIDED.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHILATION: VAPOR IS HEAVIER THAN AIR
AND CAN CAUSE SUFFOCATION BY REDUCING OXYGEN AVAILABLE FOR
BREATHING. EYE: LIQUID CONTACT WILL CAUSE TEMPORARY DISCOMFORT.
USUALLY NO EXTENDED EFFECT. CONTACT WIT H SPRAY MAY CAUSE
FROSTBITE. INGESTION:ALTHOUGH ORAL TOXICITY IS LOW, INGESTION IS TO
BE AVOIDED. SKIN: REPEATED LIQUID CONTACT CAN CAUSE DEFATTING OF
THE SKIN. THIS MATERIAL IS POORLY ABSORBED THROUG H THE SKIN.
CONTACT WITH SPRAY MAY CAUSE FROSTBITE.
Explanation of Carcinogenicity:COMPONENTS ARE NOT LISTED AS CARCINOGENS
BY IARC OR NTP. OSHA REGULATED YES; OSHA AIR CONTAINMENT,TOXIC -
YES; LOW TOXICITY.
Effects of Overexposure:INHILATION:BREATHING HIGH CONCENTRATIONS OF
VAPOR CAN CAUSE LIGHT-HEADEDNESS, GIDDINESS, SHORTNESS OF BREATH,
HEADACHE AND MAY LEAD TO NARCOSIS, CARDIAC IRREGULARITIES,
CIRCULATORY SYSTEM DEPRESSION, UNCONSCIOUSNESS OR DEATH. EYE:
CONTACT WILL CAUSE DISCOMFORT. INGESTION: MAY CAUSE NAUSEA AND
VOMITING. SKIN: IRRITATION OR REDDENING MAY OCCUR DUE TO DEFATTING.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE

First Aid:INHALATION: REMOVE TO FRESH AIR AND CALL PHYSICIAN. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION, PREFERRABLY MOUTH-TO-MOUTH.
IF BREATHING DIFFICULT, GIVE OXYGEN. DO NOT GIVE
EPINEPHRINE/SIMILAR DRUG S. EYE: IMMEDIATELY FLUSH WITH WATER FOR15
MINUTES. SEEK MEDICAL ATTENTION. INGESTION: NO SPECIFIC
INTERVENTION IS INDICATED AS THE COMPOUND IS NOT LIKELY TO BE
HAZARDOUS BY INGESTION. CONSULT PHYSICI AN IF NECESSARY. DO NOT
INDUCE VOMITING AS THE HAZARD OF ASPIRATING MATERIAL INTO LUNGS IS
A GREATER HAZARD THAN ALLOWING IT TO PASS THROUGH INTESTIONAL
TRACT. SKIN: FLUSH WITH WATER. IF IRRITATION OC CURS/PERSISTS, SEEK
MEDICAL ATTENTION.

Flash Point Method:TOC
Flash Point:NONE
Lower Limits:N/FLAMMABLE
Upper Limits:N/FLAMMABLE
Extinguishing Media:NONFLAMMABLE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS (SCBA) MAY
BE REQUIRED IF CONTAINERS RUPTURE AND CONTENTS ARE RELEASED UNDER
FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CONTAINERS MAY VENT,
RUPTURE OR EXPLODE AND ADD FLYING AND FALLING DEBRIS. DECOMPOSITION
MAY OCCUR.

Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION. COLLECT SPILLED PRODUCT WITH ABSORBENT
MATERIAL AND PLACE IN CLOSED STEEL DRUM FOR PROPER DISPOSAL. SARA
311 QUANTITY: 5,000.00. UNITS OF MEASURE: LB.
Neutralizing Agent:NOT RELEVANT.

Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT, OR WHERE TEMPERATURE EXCEEDS 120F. DO NOT PUNCTURE
OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS
SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY
PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1988 (40 CFR 372).
CAS#76-13-1;CHEMICA L NAME:TRICHLOROTRIFLUOROETHANE;PERCENTBY
WEIGHT:61.62. CONTAINS CHEMICALS LISTED ON TSCA INVENTORY: YES.

Respiratory Protection:NO. GOOD VENTILATION/H.C. RESP.
Ventilation:NO. AS NEEDED TO COMPLY WITH TLV
Protective Gloves:BUTYL
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE BATH AND PROTECTIVE CLOTHES
Work Hygienic Practices:NORMAL VENTILATION FOR STANDARD MANUFACTURING
PROCEDURE IS GENERALLY ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN
LARGE AMOUNTS ARE RELEASED. MECHANICAL VENTILATION SHOULD BE USED
IN LOW PLACES.
Supplemental Safety and Health
NONE

HCC:V2
Boiling Pt:=23.9C, 75.F
B.P. Text:75-118F
Vapor Pres:334MMHG@77F
Vapor Density:4.6
Spec Gravity:1.46
Evaporation Rate & Reference:>1(BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS,LIQUID WITH FAINT SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
ALKALI AND ALKALINE EARTH METALS-POWDERED AL,ZN,BE,OR MG.
Stability Condition to Avoid:DO NOT HEAT AEROSOL CONTAINERS ABOVE
120F/49C.AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT SURFACES.
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS
AND POSSIBLY CARBONYL HALIDES.

Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.

Toxicological Information:NOT PROVIDED.

Ecological:NOT PROVIDED.

SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1988 (40 CFR
372). CAS#76-13-1; CHEMIC AL NAME:TRICHLOROTRIFLUOROETHANE;
ERCENTBY WEIGHT:61.62.
Federal Regulatory Information:CONTAINS CHEMICALS LISTED ON TSCA
INVENTORY:YES.
State Regulatory Information:NOT PROVIDED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.